Fairchild C-119 Flying Boxcar
The Fairchild C-119 Flying Boxcar (Navy and Marine Corps designation R4Q) was an American military transport aircraft developed from the World War II-era Fairchild C-82 Packet, designed to carry cargo, personnel, litter patients, and mechanized equipment, and to drop cargo and troops by parachute. The first C-119 made its initial flight in November 1947, and by the time production ceased in 1955, more than 1,100 C-119s had been built. Its cargo-hauling ability and unusual appearance earned it the nickname "Flying Boxcar".
Development
The Air Force C-119 and Navy R4Q was initially a redesign of the earlier Fairchild C-82 Packet, built between 1945 and 1948. The Packet provided service to the Air Force's Tactical Air Command and Military Air Transport Service for nearly nine years during which time its design was found to have several serious problems. All of these were addressed in the C-119.
In contrast to the C-82, the cockpit was moved forward to fit flush with the nose rather than its previous location over the cargo compartment. This resulted in more usable cargo space and larger loads than the C-82 could accommodate. The C-119 also featured more powerful engines, and a wider and stronger airframe. The first C-119 prototype (called the XC-82B) first flew in November 1947, with deliveries of C-119Bs from Fairchild's Hagerstown, Maryland factory beginning in December 1949.[2]
In 1951 Henry J. Kaiser was awarded a contract to assemble additional C-119s at the Kaiser-Frazer automotive factory located in the former B-24 plant at Willow Run Airport in Belleville, Michigan. Initially, the Kaiser-built C-119F would differ from the Fairchild aircraft by the use of Wright R-3350-85 Duplex Cyclone engines in place of Fairchild's use of the Pratt & Whitney R-4360 Wasp Major radial engine. The Wright engine was a proven design used previously on the B-29, and though it lacked the R-4360's superchargers it proved to be virtually identical in performance, and possibly superior at higher altitudes. Kaiser would build 71 C-119s at Willow Run in 1952 and 1953 (s/n 51-8098 to 51-8168) before converting the factory for a planned production of the Chase C-123 that would never occur. The Kaiser sub-contract was frowned upon by Fairchild, and efforts were made through political channels to stop Kaiser's production, which may have proven successful. Following Kaiser's termination of C-119 production the contract for the C-123 was instead awarded to Fairchild. Most Kaiser-built aircraft were issued to the U.S. Marine Corps as R4Q, with several turned over to the South Vietnamese Air Force in the 1970s.
The AC-119G "Shadow" variant was fitted with four six-barrel 7.62 mm miniguns, armor plating, flare launchers, and night-capable infrared equipment. Like the AC-130 it would be a potent weapon. The AC-119 was made more deadly by the introduction of the AC-119K "Stinger" version, which featured the addition of two 20 mm cannon, improved avionics, and two underwing-mounted General Electric J85-GE-17 turbojet engines, adding nearly 6,000 lbf (27 kN) of thrust.
Other major variants included the EC-119J, used for satellite tracking, and the YC-119H Skyvan prototype, with larger wings and tail.
In civilian use, many C-119s feature the "Jet-Pack" modification, which incorporates a 3,400 lbf (15,000 N) Westinghouse J34 turbojet engine in a nacelle above the fuselage.
Production
Number Built: 1,183 consisting of:
- 1,112 built by Fairchild
- 71 built by Kaiser-Frazer Corp
Two additional airframes were built by Fairchild for static tests
Operational history
The aircraft saw extensive action during the Korean War as a troop and equipment transport. In July 1950, four C-119s were sent to FEAF for service tests. Two months later, the C-119 deployed with the 314th Troop Carrier Group and served in Korea throughout the war. In December 1950, after Chinese PLA troops blew up a bridge [N 1]at a narrow point on the evacuation route between Koto-ri and Hungnam, blocking the withdrawal of U.N. forces. Eight U.S. Air Force C-119 Flying Boxcars flown by the 314th Troop Carrier Group[4][N 2] were used to drop portable bridge sections by parachute. The bridge, consisting of eight separate sixteen-foot long, 2,900-pound sections, was dropped one section at a time, using two parachutes on each section. Four of these sections, together with additional wooden extensions were successfully reassembled into a replacement bridge by Marine Corps combat engineers and the US Army 58th Engineer Treadway Bridge Company, enabling U.N. forces to reach Hungnam.
From 1951 to 1962, C-119C, F and G models served with U.S. Air Forces in Europe (USAFE) and Far East Air Forces (FEAF) as the first-line Combat Cargo units, and did yeoman work as freight haulers with the 60th Troop Carrier Wing, the 317th Troop Carrier Wing and the 465th Troop Carrier Wing in Europe, based first in Germany and then in France with roughly 150 aircraft operating anywhere from Greenland to India. A similar number of aircraft served in the Pacific and the Far East. In 1958, the 317th absorbed the 465th, and transitioned to the C-130s, but the units of the former 60th Troop Carrier Wing, the 10th, 11th and 12th Troop Carrier Squadrons, continued to fly C-119s until 1962, the last non-Air Force Reserve and non-Air National Guard operational units to fly the "Boxcars."
The USAF Strategic Air Command had C-119 Flying Boxcars in service from 1955 to 1973.
The C-119s saw service with the 456th Troop Carrier Wing which was attached to the Strategic Air Command (SAC) from 25 April 1955 to 26 May 1956. The C-119s performed aerial recovery of high altitude balloon-borne instrument packages. C-119s from the 6593rd Test Squadron based at Hickam Air Force Base, Hawaii performed several aerial recoveries of film-return capsules during the early years of the Corona spy satellite program. On 19 August 1960 the recovery by a C-119 of film from the Corona mission code-named Discoverer 14 was the first successful recovery of film from an orbiting satellite and the first aerial recovery of an object returning from Earth orbit.[5]
The C-119 would go on to see extensive service in Vietnam, beginning in 1953 with aircraft secretly loaned by the CIA to French forces for troop support. These aircraft were generally flown in French markings by American CIA pilots often accompanied by French officers and support staff. The C-119 was to play a major role during the siege at Dien Bien Phu, where they flew into increasingly heavy fire while dropping supplies to the besieged French forces.[6] The only American casualty of the siege at Dien Bien Phu was James B. McGovern, Jr. who was killed when his C-119 was shot down while delivering a Howitzer to the besieged base.
During the Sino-Indian War of 1962, the C-119 was extensively used for supply of Indian forces. President Kennedy allowed sales of spares of C-119 on priority basis upon request by the Indian government.
During the Vietnam War, C-119G's were modified as AC-119G Shadows and AC-119K Stingers. They were used successfully in both Close Air Support missions in SVN and Interdiction missions against trucks and supplies along the Trails. All the AC-119G Gunships were transferred to the South Vietnamese in 1973 when the American phase of the Vietnam War ended.
After retirement from active duty, substantial numbers of C-119s and R4Qs soldiered on in the U.S. Navy, U.S. Marine Corps, the Air Force Reserve and the Air National Guard until the mid-1970s; until recently they were still in use by the Taiwanese Air Force. The last military use of the C-119 by the United States ended in 1974 when a single squadron of Navy Reserve R4Qs based at Selfridge Air National Guard Base near Detroit, Michigan, and two squadrons based at Naval Air Station Los Alamitos, California replaced their R4Qs with newer aircraft.
Many C-119s were provided to other nations as part of the Military Assistance Program, including Belgium, Brazil, Ethiopia, India, Italy, Jordan, Nationalist China, and (as previously mentioned) South Vietnam. The type was also used by the Royal Canadian Air Force, and by the United States Navy and United States Marine Corps under the designation R4Q.
Civilian use
A number of aircraft were acquired by companies who were contracted by the United States Forest Service (USFS) and the Bureau of Land Management to provide airtankers for fighting wildfires. Others were pressed into civilian cargo service. After a series of crashes, the age and safety of the aircraft being used as airtankers became a serious concern, and the U.S. C-119 airtanker fleet was permanently grounded in 1987. Many of these aircraft wound up being provided to museums across the U.S. in a complicated - and ultimately illegal - scheme where stored USAF Lockheed C-130 Hercules transports and Navy Lockheed P-3 Orion anti-submarine patrol aircraft were provided to the contractors in exchange for the C-119s.[7] (See U.S. Forest Service airtanker scandal.) After the end of the airtanker days many C-119s flew in Alaska for Northern Pacific Transport, Gifford Aviation, Stebbins & Ambler Air Transport, and Delta Associates. They can be used for public service contracts, such as hauling building materials to the villages in the bush of Alaska that have no road access.
Variants
- XC-119A
- The XC-82B modified to production standards, later became C-119A, then EC-119A as an electronics test bed.
- C-119B
- Production variant with two R-4360-30 engines, 55 built.
- C-119C
- As C-119B with dorsal fins added and tailplane extensions removed, 303 built.
- YC-119D
- Project for a version with three-wheeled landing gear and removable pod, was designated XC-128A, none built.
- YC-119E
- Project for a version of the 119D with two R-3350 engines, was designated XC-128B, none built.
- YC-119F
- One C-119C modified with two R-3350-85 engines.
- C-119F
- Production variant, 256 built for the USAF and RCAF.
- C-119G
- As C-119F with different propellers, 480 built.
- AC-119G Shadow
- C-119G modified as gunships, 26 conversions.
- YC-119H
- Re-designed version with extended wing and modified tail surface, one converted from a C-119C.
- C-119J
- C-119F and G converted with a modified rear fuselage, 62 conversions.
- EC-119J
- Conversions for satellite tracking.
- MC-119J
- Used for aircraft equipped for medical evacuation role.
- YC-119K
- One C-119G modified with two General Electric J85 turbojets in underwing pods.
- C-119K
- Five C-119Gs modified as YC-119K.
- AC-119K Stinger
- C-119G modified to C-119K standard as gunships, 26 conversions.
- C-119L
- Modified variant of the C-119Gs, 22 conversions.
- XC-120 Packplane
- One C-119B converted with removable cargo pod.
- C-128
- Initially used designation for YC-119D and YC-119E variant.
- R4Q-1
- United States Navy & United States Marine Corps version of the C-119C, 39 built.
- R4Q-2
- United States Navy and United States Marine Corps version of the C-119F, later re-designated C-119F, 58 built.
Operators
- Belgium
- Brazil
- Brazilian Air Force received 13 former USAF aircraft.
- 2nd Squadron of the 1st Group of transporting troops
- Cambodia
- Canada
- Republic of China (Taiwan)
- Ethiopia
- France
- India
- Italy
- Italian Air Force received 40 new aircraft, five transferred from United Nations and 25 surplus USAF aircraft.
- Jordan
- Morocco
- Norway
- Spain
- South Vietnam
- United Nations
- Five former USAF aircraft donated, operated by the Indian Air Force then passed to the Italian Air Force.
- United States
Accidents and incidents
- 23 June 1953: Shortly after a ground control approached (GCA) radar monitored takeoff from Ashiya AB, Japan, an US Air Force Flying Boxcar (49-161) turned to a heading 005 degrees magnetic (dm) and began a normal climb through the overcast. The pilot then reported that the C-119 may have scraped the tail skid on takeoff; additionally all the left seat (pilot side) gyroscopic instruments (Gyros) were not operational. A few seconds later the pilot requested immediate GCA vector to Ashiya AB, stating that co-pilot would have to fly the GCA approach from the right seat. The GCA was continuously tracking the Flying Boxcar and reported its location as 12 miles north of Ashiya AB, instructing co-pilot to turn right to a heading of 210 degrees. Then 49-161 disappeared from radar. All souls on board were lost
- 10 August 1955: Two aircraft of a nine-plane USAF flight on a training mission collided over Edelweiler, Germany. One of the C-119s had developed engine trouble and lost altitude, causing it to strike another aircraft in the formation. A total of 66 people on board the two aircraft were killed.
- 12 December 1961: Two C-119s of the Belgian Air Force collided in mid-air near Chièvres, killing all 13 crew members.
- 26 June 1963: During a training mission near Detmold, a Belgian Air Force C-119 was accidentally shot down by British artillery. While nine paratroopers were able to jump out, 33 other paratroopers and all five crew members were killed when the aircraft crashed.
- 5 June 1965: 51-2680, a C-119F operated by the US Air Force disappeared on a military transport flight between Homestead Air Force Base, FL and Grand Turk Island Airport. Five crew and four air force mechanics were killed in the accident.[8]
- 6 June 1983: Shortly after takeoff, a Republic of China Air Force C-119 crashed into Formosa Strait due to engine failure. Of the 47 people on board, 38 were killed.
Survivors
A number of C-119s have been preserved in museums.
Brazil
Belgium
- C-119G serial 254, CP46/OT-CEH (Belgium Airforce), ex 53-8151. At the Royal Army and Military History Museum in Brussels.[9][10]
- C-119G serial 10690, CP10/OT-CAJ (Belgian Airforce), ex 51-2701. At Melsbroek AB [11]
India
- C-119 - IK450, Indian Air Force Museum, Palam, New Delhi. This unit is fitted with an external jet-pack.[N 3]
South Korea
United States
- Two are airworthy in Palmer, Alaska: They can be used for public service contracts, such as hauling building materials to the villages in the bush of Alaska that have no road access.[14]
- C-119J serial number 51-8037 is on display at the National Museum of the United States Air Force at Wright-Patterson AFB in Dayton, Ohio. This aircraft was specially modified for the mid-air retrieval of space capsules reentering the atmosphere from orbit. On 19 August 1960 this aircraft made the world's first mid-air recovery of a capsule returning from space when it "snagged" the parachute lowering the Discoverer XIV satellite at 8,000 feet (2,400 m) altitude 360 miles (580 km) southwest of Honolulu, Hawaii. The aircraft was delivered to the Museum in November 1963. It is on display outside, on the Museum's ramp.[15]
- C-119C AF Serial 48-0322 - At the Milestones of Flight Museum, Fox Field, Lancaster, California. Last operated by Hemet Valley Flying Service as Tanker 82, registered N13745.
- C-119C AF Serial 49-0199 - At the Castle Air Museum (former Castle AFB), Atwater, California. Transferred to the U.S. Forest Service after retirement from the Air Force.
- C-119C AF Serial 49-0132 - At the Pima Air and Space Museum adjacent to Davis-Monthan AFB in Tucson, Arizona. This aircraft also carries civilian registration N13743 and is currently in the markings of "Tanker 81" of Hemet Valley Flying Service of Hemet, California. This aircraft is currently on outdoor display and will be restored to original USAF markings.[16]
- C-119 (AF serial number unknown) Flying J Ranch near Pima, Arizona in Graham County.
- C-119 (AF serial number unknown) Battle Mountain, Nevada airport. Former tanker with "Jet-Pack" modification.
- C-119G AF serial 51-8024L - At the Strategic Air and Space Museum, adjacent to Offutt AFB in Ashland, Nebraska.[17]
- C-119 - Zenith Aviation's Tanker 140 has been donated to the Hagerstown Aviation Museum.[18]
- C-119C - AF Serial No. 50-0128, Pope AFB, North Carolina marked as 50-0182
- C-119C - AF Serial No. 49-0157 at the Pima Air and Space Museum (adjacent to Davis-Monthan AFB) in Tucson, Arizona
- R4Q BuNo 131677, s/n 10844, civil registration N175ML is on display at the Mid-Atlantic Air Museum in Reading, Pennsylvania. This former Marine R4Q is reported to be the last C-119/R4Q operated by the U.S. military.[19]
- R4Q-2 - (Bureau Number {BuNo} unknown) Painted in United States Air Force colors to depict it as a C-119 on static display at the Fort Campbell Museum at Fort Campbell, Kentucky.
- C-119G AF Serial 52-5850 - At the Grissom Air Museum, located at Grissom ARB (formerly Grissom AFB) in Peru, Indiana.
- C-119G AF Serial 52-2107 - At the Hill Aerospace Museum at Hill AFB in Ogden, Utah.
- R4Q-2 Packet, BuNo 131708, Flying Leatherneck Aviation Museum at Marine Corps Air Station Miramar, California.
- C-119G RCAF serial 22118 (c/n 10870, originally C-119F), is at the USAF Air Mobility Command Museum at Dover AFB, Delaware since 1991. After its RCAF service it was converted into an air tanker. It was restored as a C-119G, fake AF Serial No. 51-2881 [20]
- C-119G - Equipped with radar nose, on static display at the 1941 Historical Aircraft Group in Geneseo, New York
- C-119 - Pate Museum of Transportation (to be closed 12/25/09) on US377 South of Fort Worth, Texas
- C-119 - (no specifications) On display in the Air Park at Little Rock AFB, Arkansas
- C-119G - N15501, Used in the movie "Flight of the Phoenix", 2004. Currently owned by Hans Lauridsen in Arizona. Lauridsen Aviation Museum
Specifications (C-119)
General characteristics
- Crew: 5
- Capacity:
- 62 troops or
- 35 stretchers
- Payload: 10,000 lb (4,500 kg) of cargo
- Length: 86 ft 6 in (26.37 m)
- Wingspan: 109 ft 3 in (33.30 m)
- Height: 26 ft 6 in (8.08 m)
- Wing area: 1,447 ft² (134.4 m²)
- Empty weight: 40,000 lb (18,000 kg)
- Loaded weight: 64,000 lb (29,000 kg)
- Max takeoff weight: 74,000 lb (34,000 kg)
- Powerplant: 2 × Pratt & Whitney R-4360-20[N 4][N 5] radial engines, 3,500 hp (2,611 kW each) each
Performance
Popular culture
The 2004 film Flight of the Phoenix employed a C-119 instead of the C-82 Packet featured in the original 1965 film. (The aircraft in the novel is referred to as a "Skytruck".) The studio had been offered the Hawkins & Power's flyable C-82, but the director favored the more graceful lines of the C-119 for this version. A C-119G owned by Hawkins & Powers Aviation Inc. and registered as N15501 was flown to Africa with the addition of a single jet mounted on the upper surface, which was then removed for filming. Three ex-USMC C-119Fs were also used for the various wreck scenes.
An ex-RCAF C-119 water bomber also makes several appearances at the training base in the 1989 movie Always.
See also
- Related development
- Aircraft of comparable role, configuration and era
- Related lists
References
Notes
- ^ The Chinese actually blew up three bridges in succession at the same point: the original concrete span, a wooden replacement, and a third M-2 steel treadway portable bridge installed by U.S. combat engineers.[3]
- ^ Other sources state that the eight Flying Boxcars used on the bridge mission were U.S. Marine Corps R4Qs.
- ^ Another view of the C-119, also note the external jetpack on top of the fuselage for JATOs (Jet assisted take off)[12]
- ^ alternatively Wright R-3350-85 "Duplex Cyclone" radials, 2,500 hp (1,900 kW) each
- ^ C-119F and R4Q-2 had R3350-85-30WA, R3350-89-36W, or R3350-89A-36W engines.[21]
Citations
- ^ "Fairchild C-119 Flying Boxcar." globalsecurity.org. Retrieved: 19 May 2011.
- ^ Swanborough and Bowers 1963, pp. 262–263.
- ^ Mossman, Billy C., EBB AND FLOW: NOVEMBER 1950 - JULY 1951, p. 137.
- ^ Rumley, Chris, "314th delivers bridge to combat troops." litterok.af.mil, 18 May 2010. Retrieved: 12 May 2011.
- ^ "Discoverer 14 - NSSDC ID: 1960-010A." NASA. Retrieved: 28 June 2011.
- ^ Grandolini 1996, pp. 52—60.
- ^ "USA vs Fuchs." U.S. 9th Circuit Court of Appeals, Appeal 9810173, filed July 6, 2000. Retrieved: 28 June 2011.
- ^ Ranter, Harro and Fabian I. Lujan. "ASN Aircraft accident Fairchild C-119F-FA Flying Boxcar 51-2680 Bahamas." Aviation Safety Network, 2010. Retrieved: June 28, 2011.
- ^ "C-119G." Royal Army and Military History Museum Collection, Scramble (magazine). Retrieved: 28 June 2011.
- ^ "C-119G photo." wreckhunters.be. Retrieved: 28 June 2011.
- ^ "C-119G photos." wreckhunters.be. Retriev3d; 28 June 2011.
- ^ "Picture_024.jpg." Fotopic.Net. Retrieved: 28 June 2011.
- ^ "South Korea 60th Anniversary of the Korean War." naver.com. Retrieved: 28 June 2011.
- ^ "N1394N." flyingboxcar.com. Retrieved: 28 June 2011.
- ^ United States Air Force Museum Guidebook 1975, p. 53.
- ^ "Fairchild C-119C Flying Boxcar." Pima Air and Space Museum. Retrieved: 28 June 2011.
- ^ "C-119G, S/N 51-8024L." Strategic Air & Space Museum. Retrieved: 28 June 2011.
- ^ "C-119." Hagerstown Aviation Museum. Retrieved: 28 June 2011.
- ^ "Aircraft of the Mid-Atlantic Air Museum. maam.org. Retrieved: 28 June 2011.
- ^ "C-119G." amcmuseum.org. Retrieved: 28 June 2011.
- ^ C-119F/R4Q-2 Flight Handbook T.O. 1C-119F-1, 1 August 1956.
Bibliography
This article incorporates public domain material from websites or documents of the United States Air Force. Website of origin: USAF Museum
- Grandolini, Albert. "French 'Packets': Fairchild C-119 Boxcars in French Indochina". Air Enthusiast, Volume 66, November/December 1996, pp. 52–60. ISSN 5450-0143-5450.
- Swanborough, F.G. and Peter M. Bowers. United States Military Aircraft since 1909. London: Putnam, 1963.
- United States Air Force Museum Guidebook. Wright-Patterson AFB, Ohio: Air Force Museum Foundation. 1975.
External links
|
|
|
Manufacturer
designations |
|
|
| By role |
|
|
| Fairchild (Canada) |
|
|
| Fairchild-Dornier |
|
|
| Fairchild Hiller |
|
|
| Fairchild Republic |
|
|
| Fairchild Swearingen |
|
|
| American Helicopter |
|
|
See also:
Ranger/Fairchild aeroengines
|
|
|
|
|
Main sequence
1925-1962 |
|
|
Revived sequence
2005-2006 |
|
|
|
See also: Post-1962 list
|
|
|
|
|
| General |
|
|
| Military |
|
|
| Accidents/incidents |
|
|
| Records |
|
|